當前位置：常州市華夏干燥制粒設備有限公司>>干燥蒸發設備>>閃蒸干燥機

閃蒸干燥機

返回列表頁

參考價

面議

具體成交價以合同協議為準

產品型號

品牌

廠商性質經銷商

所在地

在線詢價 收藏產品

聯系方式：查查看聯系方式

更新時間：2026-09-06 07:41:18瀏覽次數：20次

聯系我時，請告知來自制藥網

產品分類 品牌分類

暫無信息

常州市華夏干燥制粒設備有限公司

經營模式：經銷商

商鋪產品：36條

所在地區：江蘇

聯系人：查（總經理）

詢價 給他留言

產品簡介

閃蒸干燥機（CE） SpinFlashDryingEquipment (CEApproved)1.原理(Principles)：熱空氣由入口管以適宜的噴動速度從干燥機底部進入攪拌粉碎干燥室，對物料產生強烈的剪切、吹浮、旋轉作用，于是物料受到離心、剪切、碰撞、摩擦而被微?；?，強化了傳質傳熱

詳細介紹

閃蒸干燥機（CE）
Spin Flash Drying Equipment (CE Approved)

1. 原理( Principles )：
熱空氣由入口管以適宜的噴動速度從干燥機底部進入攪拌粉碎干燥室，對物料產生強烈的剪切、吹浮、旋轉作用，于是物料受到離心、剪切、碰撞、摩擦而被微?；瑥?qiáng)化了傳質傳熱。在干燥機底部，較大較濕的顆粒團在攪拌器的作用下被機械粉碎，濕含量較低、顆粒度較小的顆粒被旋轉氣流夾帶上升，在上升過程中進一步干燥。由于氣固兩相作旋轉流動，固相慣性大于氣相，固氣兩相間的相對速度較大，強化兩相間的傳質傳熱，所以該機生產強度高。
Hot air is sprayed from the bottom of the dryer into a drying chamber, which is used for stirring and crushing, at a proper speed. It causes the materials to float and rotate at a high speed. Thus, the materials are granulated through centrifuging, shearing, impacting and rubbing. And the process of heat transmitting is also strengthened. At the bottom of the dryer, large and damp, lump granules are crushed under the action of the stirrer. While small granules contain less moisture will be brought up by the rotating air flow. During this period. They are dried further. As the inertia of the solid is larger than that of gas, the solid and gas will flow rotairly at a high relative speed. So the process of heat transmitting will be strengthened again. Therefore the machine has a high drying capacity.
2. 特點( Featurs)：
◆由于物料受到離心、剪切、碰撞、摩擦而被微粒化，呈高度分散狀態及固氣兩相間的相對速度較大，強化了傳質傳熱，故該機生產強度高。

◆干燥氣體進入干燥機底部，產生強烈的旋轉氣流，對器壁上物料產生強烈的沖刷帶出作用，消除粘壁現象。

◆在干燥機底部高溫區，熱敏性物料不與熱表面直接觸，并裝有特殊裝置，解決了熱敏性物料的焦化變色問題。

◆由于干燥室內周向氣速高，物料停留時間短，達到高效、快速、小設備、大生產。

◆干燥室上部加裝淘析環及旋流片，可控制出口物流的粒度及濕度，以達到不同物料的終水份粒度的要求。
◆ As the materials are granuled through centrifuging, shearing, impacting and rubbing. Moreover the relation velocity between solid and gas phases is high, so it strengthens the process of heat transmitting. Therefore the machine has a high drying capacity.
◆ Dry gas enters the dryer the from bottom which produces strong rotating air flow and also carries out an action of strong rushing onto the raw materials on the inner wall of the dryer. So there is no phenomenon of materials sticking on the inner wall.
◆ At the bottom of the dryer, where the temperature is very high, a special device is equipped to prevent heat sensitive materials from contacting with the heat surface directly. Therefore, it solves the problem of heat sensitive materials carbonization and color changing.
◆ As the rotating speed of the gas inside the drying chamber is very high and the staying time of the materials is very short, high efficiency, high drying speed, small equipment, large out put can be achieved.
◆ There are elutrating rings and rotating flow separators equipped in the upper part of the drying chamber in order to control the size and humidity of the granules so as to meet different requirements.
3. 應用范圍(Scope of application)：
◆有機物：阿特拉津（農藥殺蟲劑）、月桂酸隔、苯甲酸、安息香酸、殺菌丹、草酸鈉、醋酸纖維素等。
◆染料：蒽醌、黑色氧化鐵、靛蘭顏料、丁酸、氫氧化鈦、硫化鋅、各種偶氮染料中間體。
◆無機物：硼砂、碳酸鈣、氫氧化物、硫酸銅、氧化鐵、碳酸鋇、三氧化銻、各種金屬氫氧化物、各種重金屬鹽、合成冰晶石等。
◆陶瓷：高嶺土、三氧化硅、粘土等。
◆食品：大豆蛋白、膠凝淀粉、酒糟、小麥糖、小麥淀粉等。
◆ Organic compounds: Fenatrol(insecticide of agrochemicals),cadmium laurate, benzoic acid, germicide, sodium oxalate, cellulose acetate and so on.
◆ Dyestuff: anthraquinone, black ferric oxide, indigo blue pigment, butyric acid, titanium hydroxide, zinc sulfide, all kinds of intermediate of azo dye-stuff.
◆ Inorganic compounds: borax, calcium carbonate , hydroxide, copper sulfate, ferric oxide , barium carbonate , antimony trioxide, all kind of heavy metallic salt, synthetic cryolite and so on.
◆ Ceramics: kaoline, silicone trioxide, clay and so on. Foodstuff: soya protein, agglomerative starch, lees, trticin, wheat starch and so.
4、技術參數Technical parameter

型號Type	直徑Diameter of the cylinder （mm）	主機尺寸Main machine dimensions（mm）	主機功率Main machine power （Kw）	風量Volume of hot air （m3/h）	水分蒸發量Water evaporation （Kg/h）	占地面積Occupied area （mm2）
XZG-2	200	250 ×2800	5~9	300~800	10~20	3500 ×2500
XZG-3	300	400 ×3300	8~15	600~1300	20~50	3800 ×2700
XZG-4	400	500 ×3500	10~17.5	1250~2500	25~70	4000 ×3000
XZG-5	500	600 ×4000	12~24	1500~4000	30~100	4200 ×3200
XZG-6	600	700 ×4200	20~29	2500~5000	40~200	4250 ×3250
XZG-8	800	900 ×4600	24~35	3000~8000	60~600	4500 ×3500
XZG-10	1000	1000 ×5000	40~62	5000~12500	100~1000	4750 ×3750
XZG-12	1200	1300 ×5200	50~89	10000~20000	150~1300	5000 ×4000
XZG-14	1400	1500 ×5400	60~105	14000~27000	200~1600	5250 ×4250
XZG-16	1600	1700 ×6000	70~105	18700~36000	250~2000	5500 ×4500
XZG-18	1800	2000×8000	90~165	36000~45780	300~3000	6500×5500
XZG-20	2000	2200×12000	135~220	45000~56520	500~5000	7500×6500